Anti-browning effect of Rosa roxburghii on apple juice and identification of polyphenol oxidase inhibitors.

Enzymatic browning control of cloudy fruit juice with natural substances has received much attention for improving its nutritional and commercial value. This study explored the anti-browning potential of Rosa roxburghii in apple juice. The anti-browning effects and mechanisms were evaluated by serial measurements of appearance, browning index, polyphenol oxidase (PPO) activity, UPLC-QE-Orbitrap-MS identification, inhibition kinetics and molecular docking. The results showed that Rosa roxburghii juice (0.25%-1.25% w/w) could effectively inhibit browning and PPO activity of apple juice. Ascorbic acid (1.67 g/100 g) as a reducing agent was a main anti-browning factor. Furthermore, seven phenolic compounds in Rosa roxburghii were screened as PPO inhibitors. Representative phenolic inhibitors induced mixed or competitive inhibition of PPO, mainly driven by hydrophobic forces and hydrogen bonds. This work demonstrates that Rosa roxburghii is a promising natural anti-browning ingredient to control the browning of cloudy apple juice due to abundant ascorbic acid and PPO inhibitors.

Yu K ，Zhou L ，Sun Y ，Zeng Z ，Chen H ，Liu J ，Zou L ，Liu W ... -  《-》

Green tea extract as an anti-browning agent for cloudy apple juice.

Enzymatic browning of fruits and vegetables and their products is an important factor worsening their quality. The influence of five green tea extracts at the concentrations of 1 g L-1 , 2 g L-1 and 3 g L-1 on polyphenol oxidase (PPO) activity in fresh cloudy apple juice was investigated. Moreover, PPO inhibition by tea extract and colour stability of juice during short-time refrigerated storage was studied. The changes of juice colour during storage was expressed as the total colour differences (ΔE*), browning index (BI), yellowness index (YI), and the absorbance at 420 nm (A420 ). All extracts inhibited PPO activity in fresh apple juice in concentration-dependent manner. PPO activity in pure apple juice decreased by 7% after 48 h, whereas PPO activity in samples with 1 g L-1 , 2 g L-1 and 3 g L-1 tea extract decreased by 53%, 74%, and 96%, respectively. Browning of apple juice during storage decreased with increased concentration of green tea extract. After 48 h, extract at 1 g L-1 , 2 g L-1 and 3 g L-1 inhibited browning of juice expressed as BI by 48%, 60%, and 86%, respectively, comparing to pure apple juice. Green tea extract may be an effective anti-browning agent for short-time stored cloudy apple juices. © 2016 Society of Chemical Industry.

Klimczak I ，Gliszczyńska-Świgło A 《-》

The potential of kiwifruit puree as a clean label ingredient to stabilize high pressure pasteurized cloudy apple juice during storage.

In the fruit juice industry, high pressure (HP) processing has become a commercial success. However, enzymatic browning, cloud loss, and flavor changes during storage remain challenges. The aim of this study is to combine kiwifruit puree and HP pasteurization (600 MPa/3 min) to stabilize cloudy apple juice during storage at 4 °C. A wide range of targeted and untargeted quality characteristics was evaluated using a multivariate approach. Due to high ascorbic acid content and high viscosity, kiwifruit puree allowed to prevent enzymatic browning and phase separation of an apple-kiwifruit mixed juice. Besides, no clear changes in organic acids, viscosity, and particle size distribution were detected in mixed juice during storage. Sucrose of apple and mixed juices decreased with glucose and fructose increasing during storage. The volatile changes of both juices behaved similar, mainly esters being degraded. Sensory evaluation demonstrated consumer preferred the aroma of mixed juice compared to apple juice.

Yi J ，Kebede B ，Kristiani K ，Buvé C ，Van Loey A ，Grauwet T ，Hendrickx M ... -  《-》

Minimizing quality changes of cloudy apple juice: The use of kiwifruit puree and high pressure homogenization.

Cloud loss, enzymatic browning, and flavor changes are important quality defects of cloudy fruit juices determining consumer acceptability. The development of clean label options to overcome such quality problems is currently of high interest. Therefore, this study investigated the effect of kiwifruit puree (clean label ingredient) and high pressure homogenization on quality changes of cloudy apple juice using a multivariate approach. The use of kiwifruit puree addition and high pressure homogenization resulted in a juice with improved uniformity and cloud stability by reducing particle size and increasing viscosity and yield stress (p < 0.01). Furthermore, kiwifruit puree addition reduced enzymatic browning (ΔE∗ < 3), due to the increased ascorbic acid and contributed to a more saturated and bright yellow color, a better taste balance, and a more fruity aroma of juice. This work demonstrates that clean label options to control quality degradation of cloudy fruit juice might offer new opportunities.

Yi J ，Kebede B ，Kristiani K ，Grauwet T ，Van Loey A ，Hendrickx M ... -  《-》

Efficacy of phytic acid as an inhibitor of enzymatic and non-enzymatic browning in apple juice.

Browning decreases the commercial value of apple juice, and therefore colour preservation during processing and storage is the main objective of manufacturers. In this study, the efficacy of phytic acid as a browning inhibitor for use on apple juice was investigated. Browning of apple juice treated with phytic acid was monitored during processing and storage. 0.1 mM Phytic acid inhibited the polyphenol oxidase (PPO) from the apple juice by 99.2%. Consequently, the apple juice treated with phytic acid had significantly lower browning formation during processing and after 6 months of storage at room temperature compared with the control (p<0.05). Results indicate that this is a promising way to inhibit browning in apple juice.

Du Y ，Dou S ，Wu S 《-》