Improvement of lipid content of Chlorella minutissima MCC 5 for biodiesel production.

Lipids extracted from microalgae have been considered as a potential source for the production of biodiesel. Enhancement of lipid has the limitations of low biomass productivity. So, the main objective of the present study was to deduce suitable conditions for the improvement of biomass production followed by enhancement of lipid content. After optimization, a strategy for two stage cultivation was utilized where high lipid content was obtained with a high biomass concentration. Optimization of biomass production of Chlorella minutissima MCC 5 was carried out under different intensities of light, temperatures, concentrations of nitrate and phosphate using Taguchi model. A suitable synergy of the four parameters yielded maximum biomass (1.93 g L(-1)) in airlift reactor. Temperature was found to be relatively effective than other parameters for higher biomass production. Activation energy for the cell growth was determined (47.95 kJ mol(-1)). Among the various (photo, thermal, nitrate and phosphate) stress conditions studied, nitrate limitation (1 mM) was found to be suitable for the enhancement of lipid resulting highest yield (48.26% w/w). Two stage cultivation of the microalgae yielded a maximum lipid content of 46% w/w with a biomass concentration of 2.2 g L(-1). Additionally, FAME analysis exhibited significant increase of oleic acid in the biodiesel. So, C. minutissima MCC 5 cultivated under nitrate stress could be a possible feedstock for biodiesel production.

Chakraborty S ，Mohanty D ，Ghosh S ，Das D ... -  《-》

Effects of various abiotic factors on biomass growth and lipid yield of Chlorella minutissima for sustainable biodiesel production.

Chandra R ，Amit ，Ghosh UK 《-》

Culture of microalgae Chlorella minutissima for biodiesel feedstock production.

Microalgae are among the most promising of non-food based biomass fuel feedstock alternatives. Algal biofuels production is challenged by limited oil content, growth rate, and economical cultivation. To develop the optimum cultivation conditions for increasing biofuels feedstock production, the effect of light source, light intensity, photoperiod, and nitrogen starvation on the growth rate, cell density, and lipid content of Chlorella minutissima were studied. The fatty acid content and composition of Chlorella minutissima were also investigated under the above conditions. Fluorescent lights were more effective than red or white light-emitting diodes for algal growth. Increasing light intensity resulted in more rapid algal growth, while increasing the period of light also significantly increased biomass productivity. Our results showed that the lipid and triacylglycerol content were increased under N starvation conditions. Thus, a two-phase strategy with an initial nutrient-sufficient reactor followed by a nutrient deprivation strategy could likely balance the desire for rapid and high biomass generation (124 mg/L) with a high oil content (50%) of Chlorella minutissima to maximize the total amount of oil produced for biodiesel production. Moreover, methyl palmitate (C16:0), methyl oleate (C18:1), methyl linoleate (C18:2), and methyl linolenate (C18:3) are the major components of Chlorella minutissima derived FAME, and choice of light source, intensity, and N starvation impacted the FAME composition of Chlorella minutissima. The optimized cultivation conditions resulted in higher growth rate, cell density, and oil content, making Chlorella minutissima a potentially suitable organism for biodiesel feedstock production.

Tang H ，Chen M ，Garcia ME ，Abunasser N ，Ng KY ，Salley SO ... -  《-》

The enhanced lipid productivity of Chlorella minutissima and Chlorella pyrenoidosa by carbon coupling nitrogen manipulation for biodiesel production.

Bharte S ，Desai K 《-》

Enhanced biodiesel production through phyco-myco co-cultivation of Chlorella minutissima and Aspergillus awamori: An integrated approach.

Algae-fungus co-culture was investigated as an alternative biodiesel feedstock. An oleaginous filamentous fungus Aspergillus awamori was co-cultured with Chlorella minutissima MCC 27 and Chlorella minutissima UTEX 2219, respectively in N11 medium furnished with different carbon and nitrogen sources. The biomass and lipid production potential of the two C. minutissima-A. awamori co-cultures was compared against the monocultures. A substantial enhancement in biomass and lipid accumulation was observed in both the co-cultures. When supplemented with different carbon and nitrogen sources, glycerol and potassium nitrate were found to be the most effective. In the presence of glycerol, a 2.6-3.9-fold increase of biomass and 3.4-5.1-fold increase of total lipid yields were observed in the co-cultures as compared to the axenic monocultures. Furthermore, C16:0 (31.26-35.02%) and C18:1 (21.14-24.21%) fatty acids were the major composites of the co-culture oils, which suggest co-culture as a promising strategy for biodiesel production.

Dash A ，Banerjee R 《-》